WASHINGTON — After a decade of work and billions of dollars spent, the modernization of the U.S. air traffic control system is in trouble. The ambitious and complex technology program dubbed NextGen has encountered unforeseen difficulties at almost every turn.
The program was promoted as a way to accommodate an anticipated surge in air travel, reduce fuel consumption and improve safety and efficiency.
By shifting from radar-based navigation and radio communications — technologies rooted in the first half of the 20th century — to satellite-based navigation and digital communications, it would handle three times as many planes by 2025, the Federal Aviation Administration (FAA) promised.
Planes would fly directly to their destinations using GPS instead of following indirect routes to stay within the range of ground stations. They would continually broadcast their exact positions, not only to air traffic controllers, but to other similarly equipped aircraft.
- Update: Seahawks' Jimmy Graham suffers right knee injury vs. Steelers, will miss rest of season
- On his birthday, Russell Wilson gives Seattle Seahawks perhaps his greatest game to beat Pittsburgh Steelers
- Suspected burglar dies after getting stuck in chimney
- Seattle Seahawks’ swagger, hopes for playoffs are back after they slam door on Pittsburgh Steelers
- Grading the game: Seattle Seahawks’ offense earns perfect mark against Pittsburgh Steelers
Most Read Stories
For the first time, pilots would be able to see on cockpit displays where they were in relation to other planes. That would enable planes to safely fly closer together, and even shift some of the responsibility for a safe separation from controllers to pilots.
But almost nothing has happened as the FAA anticipated.
Increasing capacity is no longer as urgent as it once seemed. The 1 billion passengers a year the FAA predicted by 2014 has been shoved back to 2027.
Air traffic operations — takeoffs, landings and other procedures — are down 26 percent from their peak in 2000, although chronic congestion at some large airports can slow flights across the country.
Difficulties have cropped up nearly everywhere, from new landing procedures that were impossible for some planes to fly, to aircraft-tracking software that misidentified planes.
Key initiatives are experiencing delays and are at risk of cost overruns.
And the agency still lacks “an executable plan” for bringing NextGen fully online, according to a government watchdog.
“In the early stages, the message seemed to be that NextGen implementation was going to be pretty easy: You’re going to flip a switch, you’re going to get NextGen, we’re going to get capacity gains,” said Christopher Oswald, vice president for safety and regulatory affairs at Airports Council International-North America. “It wasn’t realistically presented.”
Some airline officials, frustrated that they haven’t seen promised money-saving benefits, say they want better results before they spend more to equip planes to use NextGen, a step vital to its success.
Lawmakers, too, are frustrated. NextGen has enjoyed broad bipartisan support in Congress, but with the government facing more automatic spending cuts, supporters fear the program will be increasingly starved for money.
“It’s hard not to be worried about NextGen funding … because it’s a future system,” said Marion Blakey, who was the head of the FAA when Congress authorized the program in 2003. “There is a temptation to say the priority is keeping the existing systems humming and we’ll just postpone NextGen,” said Blakey, who now leads a trade association that includes NextGen contractors.
In September, a government-industry advisory committee recommended that, given the likelihood of budget cuts, the FAA should concentrate on just 11 NextGen initiatives that are ready or nearly ready to come online. It said the rest of the 150 initiatives can wait.
“You can’t have an infrastructure project that is the equivalent of what the (interstate) highway program was back in the ’50s and the ’60s and take this ad hoc, hodgepodge approach to moving this thing forward,” said Air Line Pilots Association First Vice President Sean Cassidy, who helped draft the recommendations.
The threat of funding cuts comes just as NextGen is nearing a tipping point where economic and other benefits should start to multiply if only the FAA and industry would persevere, said Alaska Airlines Chairman Bill Ayer, a supporter.
Responding to industry complaints, the FAA has zeroed in on an element of NextGen that promises near-term benefits: new procedures that save time and fuel in landings while decreasing greenhouse gas emissions.
Planes equipped with highly calibrated GPS navigation are able fly precise, continuous descents on low power all the way to the runway rather than the customary and time-consuming stair-step approaches in which pilots repeatedly decrease power to descend, then increase power to level off.
Last spring, Seattle-Tacoma International Airport became the first large airport where airlines can consistently use one of the new procedures.
Known as HAWKS, the method shortens the approach from the southwest by about 42 miles. Multiplied over many planes every day it adds to up to significant savings, an enticing prospect for airlines, which typically operate on razor-thin profit margins.
Alaska estimates new procedures there will eventually cut the airline’s fuel consumption by 2.1 million gallons annually and reduce carbon emissions by 24,250 tons, the equivalent of taking 4,100 cars off the road every year.
Fuel is the biggest expense for most airlines.
In Atlanta, more precise navigation procedures have increased the number of departure paths that planes can fly at the same time, resulting in more takeoffs in a shorter period of time. That has freed up an additional runway for arrivals, said Dale Wright, the National Air Traffic Controllers Association’s safety and technology director.
FAA Administrator Michael Huerta says NextGen is on track despite the troubles.
“It’s a significant transformation that we’re making,” he told The Associated Press. “I would hope it would be moving faster as well, but we have a very large, a very complex system, and we’re making great progress.”
Another important NextGen initiative would replace radio communications between controllers and pilots with text messaging and digital downloads.
Radio frequencies are often crowded, and information sometimes must be repeated because of mistakes or words not heard. Digital communications are expected to be safer and more efficient.
NextGen was originally forecast to cost $40 billion, split between government and industry, and to be completed by 2025. But an internal FAA report estimates it will cost three times that much and take 10 years longer to complete, said Calvin Scovel, the Transportation Department’s inspector general. FAA officials have largely stopped talking about end dates and completion costs as the technologies that make up NextGen continue to evolve.
The agency currently spends about $800 million a year on the program.
“When we’re talking about NextGen, it’s like we’re talking about the atmosphere,” Cassidy said. “It’s tough to pin down exactly what NextGen is in terms of the technologies and the cost of the technologies because, frankly, they’re changing all the time.”
Hopefully the FAA can make a “midcourse correction” to get NextGen on track, said U.S. Rep. Rick Larsen, D-Lake Stevens, a supporter. “We shouldn’t give up on the effort because I think everybody understands there is a lot of benefit to it.”
But he’s concerned that more delays in the program “could force us to rename it LastGen.”